RETRACTED ARTICLE: Effect of a marine bacterial biofilm on adhesion and retention of pseudo barnacle to silicone coating surface

Ho-Sup Jung; Keesung Kim; Jin Hwan Ko

Korean Journal of Chemical Engineering, Vol.31, No.2, 262-267, February, 2014

DOI10.1007/s11814-013-0218-1 Export Citation

RETRACTED ARTICLE: Effect of a marine bacterial biofilm on adhesion and retention of pseudo barnacle to silicone coating surface

Ho-Sup Jung^{1, 2}, Keesung Kim^{1, 2}, and Jin Hwan Ko^{3, †}

¹School of Mechanical and Aerospace Engineering, Seoul National University, Seoul 151-742, Korea
²Institute of Advanced Machinery and Design (IAMD), Seoul National University, Seoul 151-742, Korea
³Coastal Engineering & Ocean Energy Research Department, Korea Institute of Ocean Science and Technology, 1270, Sa-dong, Ansan 426-744, Korea

E-mail:

The effect of a marine bacterial Cytophaga lytica (C. lytica) biofilm on the adhesion and retention of a pseudobarnacle (epoxy adhesive) to platinum-cured silicone coatings was investigated at varying coating thickness (100-800 μm), modulus (E=0.08-1.3MPa), and shear rate (2-22 μm/s). The initial adhesion of C. lytica biofilm on the silicone coating surfaces was increased as the coating modulus was increased. Nonetheless, the adhesion strength of the pseudobarnacle was not significantly influenced by the attached biofilms, with its strength decreasing with increasing the coating modulus. Thus, these results suggest that the pseudobarnacle adhesion strength would be primarily determined by physico-mechanical properties of the silicone coatings. Also, the adhesion/detachment tests demonstrated that the retention of the pseudobarnacle after water jetting was minimal for the soft silicone coating (VP1), which showed better performance than the widely acceptable silicone resin of DC 3140.

Keywords:Biofilm;Biofouling;Silicone Coating;Pseudobarnacle;Adhesion

[References]

Yebra DM, Kiil S, Weinell CE, Dam-Johansen K, Biofouling, 22, 22 (2006)
Omae M, Chem. Rev., 103(9), 3431 (2003)
Brady RF, Progress in Organic Coatings, 43, 188 (2001)
Brady RF, Singer IL, Biofouling, 15, 73 (2000)
Chaudhury MK, Finlay JA, Chung JY, Callow ME, Callow JA, Biofouling, 21, 41 (2005)
Chung JY, Chaudhury MK, J. Adhes., 81(10-11), 1119 (2005)
Singer IL, Kohl JG, Patterson M, Biofouling, 16, 301 (2000)
Sun Y, Guo S, Walker GC, Kavanagh CJ, Swain GW, Biofouling, 20, 279 (2004)
Han MS, Choi SJ, Kim JM, Kim YH, Kim WN, Lee HS, Sung JY, Macromol. Res., 17(1), 44 (2009)
Stein J, Truby K, Wood C, Stein J, Gardner M, Swain G, Kavanagh CJ, Kovach B, Schultz M, Wiebe D, Holm E, Montemarano J, Wendt D, Smith C, Meyer A, Biofouling, 19, 71 (2003)
Truby K, Wood C, Stein J, Cella J, Carpenter J, Kavanagh C, Swain G, Wiebe D, Lapota D, Meyer A, Holm E, Wendt D, Smith C, Biofouling, 15, 141 (2000)
Wahl M, Mar. Ecol. Prog. Ser., 58, 175 (1989)
Abarzua S, Jakubowski S, Mar. Ecol. Prog. Ser., 123, 301 (1995)
Loeb GI, Neihof RA, Advances in Chemistry Series, 145, 319 (1975)
Huang S, Hadfield MG, Mar. Ecol. Prog. Ser., 260, 161 (2003)
Maki JS, Mitchell R, Bull. Mar. Sci., 37, 675 (1985)
Dexter SC, Sullivan JD, Williams J, Watson SW, Appl. Microbiol., 30, 298 (1975)
Dexter SC, J. Colloid Interface Sci., 70, 346 (1979)
Baier RE, Bitton G, Marshall KC(Ed.), Adsorption of microorganisms to surfaces, John Wiley & Sons, 58 (1980)
Callow ME, Fletcher RL, International Biodeterioration & Biodegradation, 24, 333 (1994)
Stafslien SJ, Daniels J, Mayo B, Christianson D, Chisholm B, Ekin A, Webster D, Swain G, Biofouling, 23, 45 (2007)
Sperling LH, Introduction to physical polymer science, Wiley and Sons, 2nd Ed., 428 (1992)
Stafslien SJ, Bahr JA, Feser JM, Weisz JC, Chisholm BJ, Ready TE, Boudjouk P, J. Comb. Chem., 8, 156 (2006)
Kim J, Chisholm BJ, Bahr J, Biofouling, 23, 113 (2007)
Owens DK, Wendt RC, J. Appl. Polym. Sci., 13, 1741 (1969)
Grasland B, Mitalane J, Briandet R, Quemener E, Meylheuc T, Linossier I, Vallee-Rehel K, Haras D, Biofouling, 19, 307 (2003)
Perbrey RS, Marshall KC, Schneider RP, Appl. Environ. Microbiol., 65, 2877 (1999)
Gray NL, Banta WC, Loeb GI, Biofouling, 18, 269 (2002)
Bakker DP, Huijs FM, de Vries J, Klijnstra JW, Busscher HJ, van der Mei HC, Colloids Surf. B: Biointerfaces, 32, 179 (2003)

[1] Yebra DM, Kiil S, Weinell CE, Dam-Johansen K, Biofouling, 22, 22 (2006)

[2] Omae M, Chem. Rev., 103(9), 3431 (2003)

[3] Brady RF, Progress in Organic Coatings, 43, 188 (2001)

[4] Brady RF, Singer IL, Biofouling, 15, 73 (2000)

[5] Chaudhury MK, Finlay JA, Chung JY, Callow ME, Callow JA, Biofouling, 21, 41 (2005)

[6] Chung JY, Chaudhury MK, J. Adhes., 81(10-11), 1119 (2005)

[7] Singer IL, Kohl JG, Patterson M, Biofouling, 16, 301 (2000)

[8] Sun Y, Guo S, Walker GC, Kavanagh CJ, Swain GW, Biofouling, 20, 279 (2004)

[9] Han MS, Choi SJ, Kim JM, Kim YH, Kim WN, Lee HS, Sung JY, Macromol. Res., 17(1), 44 (2009)

[10] Stein J, Truby K, Wood C, Stein J, Gardner M, Swain G, Kavanagh CJ, Kovach B, Schultz M, Wiebe D, Holm E, Montemarano J, Wendt D, Smith C, Meyer A, Biofouling, 19, 71 (2003)

[11] Truby K, Wood C, Stein J, Cella J, Carpenter J, Kavanagh C, Swain G, Wiebe D, Lapota D, Meyer A, Holm E, Wendt D, Smith C, Biofouling, 15, 141 (2000)

[12] Wahl M, Mar. Ecol. Prog. Ser., 58, 175 (1989)

[13] Abarzua S, Jakubowski S, Mar. Ecol. Prog. Ser., 123, 301 (1995)

[14] Loeb GI, Neihof RA, Advances in Chemistry Series, 145, 319 (1975)

[15] Huang S, Hadfield MG, Mar. Ecol. Prog. Ser., 260, 161 (2003)

[16] Maki JS, Mitchell R, Bull. Mar. Sci., 37, 675 (1985)

[17] Dexter SC, Sullivan JD, Williams J, Watson SW, Appl. Microbiol., 30, 298 (1975)

[18] Dexter SC, J. Colloid Interface Sci., 70, 346 (1979)

[19] Baier RE, Bitton G, Marshall KC(Ed.), Adsorption of microorganisms to surfaces, John Wiley & Sons, 58 (1980)

[20] Callow ME, Fletcher RL, International Biodeterioration & Biodegradation, 24, 333 (1994)

[21] Stafslien SJ, Daniels J, Mayo B, Christianson D, Chisholm B, Ekin A, Webster D, Swain G, Biofouling, 23, 45 (2007)

[22] Sperling LH, Introduction to physical polymer science, Wiley and Sons, 2nd Ed., 428 (1992)

[23] Stafslien SJ, Bahr JA, Feser JM, Weisz JC, Chisholm BJ, Ready TE, Boudjouk P, J. Comb. Chem., 8, 156 (2006)

[24] Kim J, Chisholm BJ, Bahr J, Biofouling, 23, 113 (2007)

[25] Owens DK, Wendt RC, J. Appl. Polym. Sci., 13, 1741 (1969)

[26] Grasland B, Mitalane J, Briandet R, Quemener E, Meylheuc T, Linossier I, Vallee-Rehel K, Haras D, Biofouling, 19, 307 (2003)

[27] Perbrey RS, Marshall KC, Schneider RP, Appl. Environ. Microbiol., 65, 2877 (1999)

[28] Gray NL, Banta WC, Loeb GI, Biofouling, 18, 269 (2002)

[29] Bakker DP, Huijs FM, de Vries J, Klijnstra JW, Busscher HJ, van der Mei HC, Colloids Surf. B: Biointerfaces, 32, 179 (2003)