Although biodiesel is a sustainable and renewable diesel fuel, the current feedstock predominantly from edible oils limits the economic feasibility of biodiesel production and thus the development of a cost-effective non-food feedstock is really essential. In this study, approximately 21.6% of crude grease was extracted from housefly (Musca domestica L) larvae reared on swine manure, and the extracted grease was evaluated for biodiesel production concerning the variables affecting the yield of acid-catalyzed production of methyl esters and the properties of the housefly larvae-based biodiesel. The optimized process of 8:1 methanol/grease (mol/mol) with 2 vol% H2SO4 reacted at 70 C for 2 h resulted in a 95.7% conversion rate from free fatty acid (FFA) into methyl esters. A 90.3% conversion rate of triglycerides (crude grease) to its esters was obtained from alkaline trans-esterification using sodium hydroxide as catalyst. The major fatty acid components of this larvae grease were palmitic (29.1%), oleic (23.3%), palmitoletic (17.4%) and linoleic (17.2%). The housefly larvae-based biodiesel has reached the ASTM D6751-10 standard in density (881 kg/m(3)), viscosity (5.64 mm(2)/s), ester content (96.8%), flash point (145 degrees C), and cetane number (52). These findings suggest that the grease derived from swine manure-grown housefly larvae can be a feasible non-food feedstock for biodiesel production. (C) 2013 Elsevier Ltd. All rights reserved.