Using the scanning electronic microscopy, it was observed that natural zeolite possesses excellent physical characteristics as a support medium in anaerobic fluidized bed reactors (AFBR). Samples for biomass analysis were taken from two identical laboratory-scale AFBR (R-1 and R-2), which were operated with 25% of fluidization. These reactors treated distillery wastewaters (vinasses) at mesophilic temperature (30 +/- 2 degrees C). The experiments were carried out with 0.25-0.50 and 0.50-0.80 turn zeolite particle diameter in reactors R-1 and R-2, respectively. The biomass concentration attached to zeolite in both reactors was found to be in the range of 40-45 g volatile solids/l. COD removal efficiencies as high as 90% were achieved at organic loading rate (OLRs) of up to 20 g COD/l day. The volatile fatty acid (VFA) levels were always lower that the suggested limits for digester failure. The yield coefficient of methane production was 0.29 1 CH4(at STP)/g COD consumed and was virtually independent of the OLR applied. A hybridization technique (fluorescence in situ hybridization, FISH) helped determine the predominant anaerobic microorganisms that colonized the natural zeolite, which were found to be Methanosaeta and Methanosarcinaceae, observing a reduced number of sulphate reducing bacteria. The results obtained for reactors R-1 and R-2 were very similar, showing that the particle size did not significantly influence the microbial community immobilized on zeolite. (c) 2007 Elsevier Ltd. All rights reserved.