Photothermal sterilization cellulose patch with hollow gold nanoparticles

Wanho Choi; Jae Young Park; Younghun Kim

Journal of Industrial and Engineering Chemistry, Vol.95, 120-125, March, 2021

DOI10.1016/j.jiec.2020.12.012 Export Citation

Photothermal sterilization cellulose patch with hollow gold nanoparticles

Wanho Choi, Jae Young Park¹, and Younghun Kim^†

Department of Chemical Engineering, Kwangwoon University, 20 Kwangwoon-ro, Nowon-gu, Seoul 01897, Republic of Korea
¹Department of Electronic Engineering, Kwangwoon University, 20 Kwangwoon-ro, Nowon-gu, Seoul 01897, Republic of Korea

E-mail:

In this work, we prepared hollow gold nanospheres (HAuNS) with rough surfaces and strong light absorption in the NIR region. Based on as-made HAuNS materials, photothermal sterilization patches using filter paper was prepared. When 808 nm and 4 W/cm2 laser light was irradiated on the patch containing 50 ppm of HAuNS, the temperature of patch surface increased to 63 °C. The photothermal conversion efficiency of the patch was found to be 38.8% and is enhanced by the overlap between the heat emission of nearby particles in the patch. The prepared patch was placed into an Escherichia coli culture medium with irradiation of NIR (pulsed laser by manually on/off). E. coli in direct contact with patch could be killed by local heating on the patch surface. Approximately 99% of the bacteria was killed compared to control test. Therefore, this patch can be applied to wounds to block the entry of bacteria from the outside for the prevention of secondary infections and the acceleration of treatment with the photothermal effect caused by NIR irradiation.

Keywords:Photothermal;Hollow gold;Surface plasmon;Near-infrared;Cellulose patch

[References]

Chen S, Tang F, Tang L, Li L, ACS Appl. Mater. Interfaces, 9(24), 20895 (2017)
Wu MC, Deokar AR, Liao JH, Shih PY, Ling YC, ACS Nano, 7(24), 1281 (2013)
Zhang JZ, J. Phys. Chem. Lett., 1(4), 686 (2010)
Kim HS, Lee DY, Polymers, 10(6), 961 (2018)
Hussein EA Zagho MM, Nasrallah GK, Elzatahry AA, Int. J. Nanomed., 13, 2897 (2018)
Bhatia P, Verma SS, Sinha MM, Phys. Lett. A, 383(21), 2542 (2019)
Xie H, Larmour IA, Chen YC, Wark AW, Tileli V, McComb DW, Fauldsa K, Graham D, Nanoscale, 5, 765 (2013)
Yang W, Liang H, Ma S, Wang D, Huang J, Sust. Mater. Technol., 22, e00109 (2019)
Kim M, Lee JH, Nam JM, Adv. Sci., 6, 190047 (2019)
Bai LY, Yang XQ, An J, Zhang L, Zhao K, Qin MY, Fang BY, Li C, Xuan Y, Zhang XS, Zhao YD, Ma ZY, Nanotechnology, 26(31), 315701 (2015)
Pei P, Yang F, Liu J, Hu H, Du X, Hanagata N, Zhao S, Zhu Y, Biomater. Sci., 6, 1414 (2018)
Liu Z, Cheng L, Zhang L, Yang Z, Liu Z, Fang J, Biomaterials, 35, 4099 (2014)
Han S, Han K, Hong J, Yoon DY, Park C, Kim Y, ACS omega, 3, 5244 (2018)
Vanherck K, Hermans S, Verbiest T, Vankelecom I, J. Mater. Chem., 21, 6079 (2011)
Vanherck K, Vankelecom I, Verbiest T, J. Membr. Sci., 373(1-2), 5 (2011)
Wang WN, Zhang CY, Zhang ZF, Pei P, Zhou W, Zha ZB, Shao M, Qian HS, Chem. Eng. J., 381, 122630 (2020)
Gao Y, Du H, Xie Z, Li M, Zhu J, Xu J, Zhang L, Tao J, Zhu J, J. Mater. Chem. B, 7, 3644 (2019)
Deng H, Yu Z, Chen S, Fei L, Sha Q, Zhou N, Chen Z, Xu C, Carbohydr. Polym., 230, 115565 (2020)
Manohar P, Loh B, Athira S, Nachimuthu R, Hua X, Welburn SC, Leptihn S, Front. Microbiol., 1, 1434 (2020)
Lee HJ, Han SM, Kim YH, J. Ind. Eng. Chem., 58, 33 (2018)
Li L, Liu Y, Hao P, Wang Z, Fu L, Ma Z, Zhou J, Biomaterials, 41, 132 (2015)
Barbosa S, Agrawal A, Rodriguez-Lorenzo L, Pastoriza-Santos I, Alvarez-Puebla RA, Kornowski A, Weller H, Liz-Marzan LM, Langmuir, 26(18), 14943 (2010)
Preciado-Flores S, Wang D, Wheeler DA, Newhouse R, Hensel JK, Schwartzberg A, Wang L, Zhu J, Barboza-Flores M, Zhang JZ, J. Mater. Chem., 21, 2344 (2011)
Smith JL, Marmer BS, Benedict RC, J. Food Prot., 54, 166 (1991)
Forghani F, den Bakker M, Liao JY, Payton AS, Futral AN, Diez-Gonzalez F, Front. Microbiol., 10, 323 (2019)
Jiang K, Smith DA, Pinchuk A, J. Phys. Chem. C, 117, 27073 (2013)
Hong J, Park C, Kim Y, Colloids Surf. A: Physicochem. Eng. Asp., 574, 115 (2019)

[Referenced By]

[1] Chen S, Tang F, Tang L, Li L, ACS Appl. Mater. Interfaces, 9(24), 20895 (2017)

[2] Wu MC, Deokar AR, Liao JH, Shih PY, Ling YC, ACS Nano, 7(24), 1281 (2013)

[3] Zhang JZ, J. Phys. Chem. Lett., 1(4), 686 (2010)

[4] Kim HS, Lee DY, Polymers, 10(6), 961 (2018)

[5] Hussein EA Zagho MM, Nasrallah GK, Elzatahry AA, Int. J. Nanomed., 13, 2897 (2018)

[6] Bhatia P, Verma SS, Sinha MM, Phys. Lett. A, 383(21), 2542 (2019)

[7] Xie H, Larmour IA, Chen YC, Wark AW, Tileli V, McComb DW, Fauldsa K, Graham D, Nanoscale, 5, 765 (2013)

[8] Yang W, Liang H, Ma S, Wang D, Huang J, Sust. Mater. Technol., 22, e00109 (2019)

[9] Kim M, Lee JH, Nam JM, Adv. Sci., 6, 190047 (2019)

[10] Bai LY, Yang XQ, An J, Zhang L, Zhao K, Qin MY, Fang BY, Li C, Xuan Y, Zhang XS, Zhao YD, Ma ZY, Nanotechnology, 26(31), 315701 (2015)

[11] Pei P, Yang F, Liu J, Hu H, Du X, Hanagata N, Zhao S, Zhu Y, Biomater. Sci., 6, 1414 (2018)

[12] Liu Z, Cheng L, Zhang L, Yang Z, Liu Z, Fang J, Biomaterials, 35, 4099 (2014)

[13] Han S, Han K, Hong J, Yoon DY, Park C, Kim Y, ACS omega, 3, 5244 (2018)

[14] Vanherck K, Hermans S, Verbiest T, Vankelecom I, J. Mater. Chem., 21, 6079 (2011)

[15] Vanherck K, Vankelecom I, Verbiest T, J. Membr. Sci., 373(1-2), 5 (2011)

[16] Wang WN, Zhang CY, Zhang ZF, Pei P, Zhou W, Zha ZB, Shao M, Qian HS, Chem. Eng. J., 381, 122630 (2020)

[17] Gao Y, Du H, Xie Z, Li M, Zhu J, Xu J, Zhang L, Tao J, Zhu J, J. Mater. Chem. B, 7, 3644 (2019)

[18] Deng H, Yu Z, Chen S, Fei L, Sha Q, Zhou N, Chen Z, Xu C, Carbohydr. Polym., 230, 115565 (2020)

[19] Manohar P, Loh B, Athira S, Nachimuthu R, Hua X, Welburn SC, Leptihn S, Front. Microbiol., 1, 1434 (2020)

[20] Lee HJ, Han SM, Kim YH, J. Ind. Eng. Chem., 58, 33 (2018)

[21] Li L, Liu Y, Hao P, Wang Z, Fu L, Ma Z, Zhou J, Biomaterials, 41, 132 (2015)

[22] Barbosa S, Agrawal A, Rodriguez-Lorenzo L, Pastoriza-Santos I, Alvarez-Puebla RA, Kornowski A, Weller H, Liz-Marzan LM, Langmuir, 26(18), 14943 (2010)

[23] Preciado-Flores S, Wang D, Wheeler DA, Newhouse R, Hensel JK, Schwartzberg A, Wang L, Zhu J, Barboza-Flores M, Zhang JZ, J. Mater. Chem., 21, 2344 (2011)

[24] Smith JL, Marmer BS, Benedict RC, J. Food Prot., 54, 166 (1991)

[25] Forghani F, den Bakker M, Liao JY, Payton AS, Futral AN, Diez-Gonzalez F, Front. Microbiol., 10, 323 (2019)

[26] Jiang K, Smith DA, Pinchuk A, J. Phys. Chem. C, 117, 27073 (2013)

[27] Hong J, Park C, Kim Y, Colloids Surf. A: Physicochem. Eng. Asp., 574, 115 (2019)