화학공학소재연구정보센터
홈 로그인 로그아웃 연락처 사이트맵
Korean Journal of Chemical Engineering, Vol.21, No.5, 950-955, September, 2004
DOI10.1007/BF02705576  Export Citation
Adsorption Behavior of NO and CO and Their Reaction over Cobalt on Zeolite Beta
Jatuporn Wittayakun1, †, Nurak Grisdanurak2, 3, Gerald Kinger4, and Hannelore Vinek4
  • 1School of Chemistry,Institute of Science, Suranaree University of Technology, Nakhon Ratchasima, Thailand
  • 2Department of Chemical Engineering, Thammasat University, Pathumthani, Thailand
  • 3National Research Center for Environmental Hazardous Waste Management, Chulalongkorn University, Bangkok, Thailand
  • 4Institute of Material Chemistry, Vienna University of Technology, Vienna, Austria
E-mail:
Adsorption behavior of NO and CO as well as their reaction was investigated on cobalt supported zeolite beta (Co/BEA) prepared by solid-state ion exchange (SSIE) and by impregnation (IMP). By temperature programmed desorption (TPD), two NO desorption peaks at 100 and 260℃ were observed over both SSIE and IMP catalysts with complete desorption after 450℃. CO desorbed from SSIE catalyst between 50 and 200℃. In the same temperature interval negligible CO2 desorption was observed, most likely due to reaction of CO with trace of cobalt oxides. Over IMP catalysts, desorption of CO2 was found mainly at 500℃. By comparing CO TPD profiles from physical mixtures of cobalt oxides and HBEA, SSIE catalysts most likely contained cobalt cations in zeolite exchange position while IMP catalysts had cobalt in oxidic forms. The SSIE catalysts were active for NO reduction at 400 and 500℃ with a maximum conversion at 500℃. However, the activity in the presence of water and oxygen was low. Water might inhibit the reaction by blocking active sites for NO and CO, while oxygen reacted with CO to form carbon dioxide. The activity of SSIE was better than IMP catalyst.
Keywords:NO Reduction by CO;Cobalt Catalysts;Zeolite Beta;CO-SCR;Co/BEA
  1. Armor JN, Catal. Today, 26(2), 147 (1995) 
  2. Baerlocher Ch, McCusker LB, "Database of Zeolite Structures," http://www.iza-structure.org/databases/
  3. Camblor MA, Mifsud A, Perez-Pariente J, Zeolites, 11, 792 (1991) 
  4. Camblor MA, Perez-Pariente J, Zeolites, 11, 202 (1991) 
  5. Campa MC, Derossi S, Ferraris G, Indovina V, Appl. Catal. B: Environ., 8(3), 315 (1996) 
  6. Di Monte R, Fornasiero P, Kaspar J, Rumori P, Gubitosa G, Graziani M, Appl. Catal. B: Environ., 24(3-4), 157 (2000) 
  7. Hadjiivanov KI, Catal. Rev.-Sci. Eng., 42(1-2), 71 (2000) 
  8. Kim MH, Nam IS, Korean J. Chem. Eng., 18(5), 725 (2001)
  9. Kinger G, Lugstein A, Swagera R, Ebel M, Jentys A, Vinek H, Microporous Mesoporous Mater., 39, 307 (2000) 
  10. Kondarides DI, Chafik T, Verykios XE, J. Catal., 191(1), 147 (2000) 
  11. Konsolakis M, Yentekakis IV, Palermo A, Lambert RM, Appl. Catal. B: Environ., 33(4), 293 (2001) 
  12. Kunkeler PJ, Zuurdeeg BJ, van der Waal JC, van Bokhoven JA, Koningsberger DC, van Bekkum H, J. Catal., 180(2), 234 (1998) 
  13. Ohtsuka H, Tabata T, Okada O, Sabatino LMF, Bellussi G, Catal. Today, 42(1-2), 45 (1998) 
  14. Oumi Y, Mizuno R, Azuma K, Nawata S, Fukushima T, Uozumi T, Sano T, Microporous Mesoporous Mater., 49, 103 (2001) 
  15. Park YS, Lee WY, Rhee HK, Sung BP, Lee HI, Korean J. Chem. Eng., 3(2), 165 (1986)
  16. Pisanu AS, Gigola CE, Appl. Catal. B: Environ., 20(3), 179 (1999) 
  17. Seyedeyn-Azad F, Zhang DK, Catal. Today, 68(1-3), 161 (2001) 
  18. Tabata T, Ohtsuka H, Sabatino LMF, Bellussi G, Microporous Mesoporous Mater., 21, 517 (1998) 
  19. Thormahlen P, Skoglundh M, Fridell E, Andersson B, J. Catal., 188(2), 300 (1999) 
  20. Yahiro H, Iwamoto M, Appl. Catal. A: Gen., 222(1-2), 163 (2001) 
  21. Zhu CZ, Lee CW, Chong PJ, Zeolites, 17, 483 (1996)