Cationic surfactant as methane.water mass transfer enhancer for the fermentation of Methylosinus trichosporium OB3b

Kwangmin Kim; Kyeongjun Seo; Yujin Kim; Jeongmo Yang; Kyoung-Su Ha; Jinwon Lee; Choongik Kim

Journal of Industrial and Engineering Chemistry, Vol.53, 228-232, September, 2017

DOI10.1016/j.jiec.2017.04.028 Export Citation

Cationic surfactant as methane.water mass transfer enhancer for the fermentation of Methylosinus trichosporium OB3b

Kwangmin Kim, Kyeongjun Seo, Yujin Kim, Jeongmo Yang, Kyoung-Su Ha, Jinwon Lee, and Choongik Kim^†

Department of Chemical and Biomolecular Engineering, Sogang University, 35, Baekbeom-ro, Mapo-gu, Seoul 04107, Republic of Korea

E-mail:

In this paper, we conducted an investigation into the use of bubbles modified with cationic surfactants in bubble coalescence inhibition and enhancement of methane-water volumetric mass transfer rate. Various cationic surfactants including hexyltrimethylammonium bromide (HTAB), octyltrimethylam- monium bromide (OTAB), dodecyltrimethylammonium bromide (DTAB), and hexadecyltrimethylam- monium bromide (HDTAB) were added to aqueous solution and the methane-water volumetric mass transfer coefficient (kLa) values were determined for each of the solutions. Enhancement of methanewater kLa was observed from 14 h-1 to 69 h-1, depending on the cationic surfactant type and concentration. Enhanced methane-water kLa in aqueous solution by addition of cationic surfactants was employed for the fermentation of methanotroph (Methylosinus trichosporium OB3b), and cell growth rate and maximum optical density was increased by 391% and 498%, respectively.

Keywords:Cationic surfactant;Positively charged bubble;Gas-water mass transfer rate;Bubble coalescence inhibition;Methanotroph cultivation

[References]

Drogaris G, Weiland P, Chem. Eng. Sci., 38, 1501 (1983)
Fei Q, Guarnieri MT, Tao L, Laurens LM, Dowe N, Pienkos PT, Biotechnol. Adv., 32, 596 (2014)
Ahmed A, Lewis RS, Biotechnol. Bioeng., 97(5), 1080 (2007)
Van Hamme JD, Singh A, Ward OP, Microbiol. Mol. Biol. Rev., 67, 503 (2003)
Logan BE, Microbial Fuel Cells, John Wiley & Sons, 2008.
Worden R, Bredwell M, Grethlein A, Engineering issues in synthesis-gas fermentations, in: ACS Symposium Series, 1997, ACS Publications.
Bosma TN, Middeldorp PJ, Schraa G, Zehnder AJ, Environ. Sci. Technol., 31, 248 (1996)
Bouaifi M, Hebrard G, Bastoul D, Roustan M, Chem. Eng. Process., 40(2), 97 (2001)
Heerschap S, Marafino JN, McKenna K, Caran KL, Feitosa K, Colloids Surf. A: Physicochem. Eng. Asp., 487, 190 (2015)
(a) Dehghani F, Foster NR, Curr. Opin. Solid. State Mater. Sci. 7 (2003) 363; (b) Ohgaki K, Takano K, Sangawa H, Matsubara T, Nakano S, J. Chem. Eng. Jpn. 29 (1996) 478; (c) Michaels AS, Vieth WR, Barrie JA, J. Appl. Phys. 34 (1963) 1.
(a) Yakahashi M, J. Phys. Chem. B 109 (2005) 21858; (b) Chen X, Hussein M, Becker T, Eng. Life Sci. 00 (2017) 1.
Graciaa A, Morel G, Saulner P, Lachaise J, Schechter RS, J. Colloid Interface Sci., 172(1), 131 (1995)
Yang C, Dabros T, Li DQ, Czarnecki J, Masliyah JH, J. Colloid Interface Sci., 243(1), 128 (2001)
Henderson RK, Parson SA, Refferson B, Environ. Sci. Technol., 42, 4883 (2008)
(a) Kim K, Lee J, Seo K, Kim MG, Ha KS, Kim C, J. Ind. Eng. Chem. 33 (2016) 326; (b) Baz-Rodriguez SA, Botello-Alvarez JE, Estrada-Baltazar A, Vilchiz- Bravo LE, Padilla-Medina JA, Miranda-Lopez R, Chem. Eng. Res. Des. 11 (2014) 2352.
(a) Zhu H, Shanks BH, Heindel TJ, Ind. Eng. Chem. Res. 48 (2009) 3206; (b) Craig V, Ninham B, Pashley R, Nature 364 (1993) 317.319.
(a) Ducker WA, Xu Z, Israelachvili JN, Langmuir 10 (1994) 3279; (b) Du X, Zhao L, He X, Chen H, Fang W, Li X, Chem. Eng. J. 160 (2017) 72.
(a) Vittal R, Gomathi H, Kim K, Adv. Colloid Interface Sci. 119 (2006) 55; (b) Ninham BW, Pashley RM, Nostro PL, Curr. Opin. Colloid & Interface Sci. 27 (2017) 25.
Asgharpour M, Mehrnia MR, Mostoufi N, Biochem. Eng. J., 49, 351 (2010)
(a) Jasna H, Ivankovic T, Open Life Sci. 2 (2007) 405; (b) Nye JV, Guerin WF, Boyd SA, Environ. Sci. Technol. 28 (1994) 944; (c) Tozum-Calgan SRD, Atay-Guneyman NZ, J. Environ. Sci. Health A 29 (1994) 355.
Anastasiou AD, Kazakis NA, Mouza AA, Paras SV, Chem. Eng. Sci., 65(22), 5872 (2010)
Cho S, Kim J, Chun J, Kim J, Colloids Surf. A: Physicochem. Eng. Asp., 269, 28 (2005)
Lee J, Kim K, Chang IS, Kim MG, Ha KS, Lee EY, Lee JW, Kim C, J. Mol. Liq., 215, 154 (2016)
(a) Riet KV, Ind. Eng. Chem. Process Des. Dev. 18 (1979) 357; (b) Kim K, Kwon T, Sung BJ, Kim C, J. Colloid Interface Sci. 15 (2017) 113.
Hwang IY, Hur DH, Lee JH, Park CH, Chang IS, Lee JW, Lee EY, J. Microbiol. Biotechnol., 25, 375 (2015)
Kadic E, Heindel TJ, An Introduction to Bioreactor Hydrodynamics and Gas. Liquid Mass Transfer, John Wiley & Sons, 2014.
Yasin M, Park S, Jeong Y, Lee EY, Lee J, Chang IS, Bioresour. Technol., 169, 637 (2014)
Creux P, Lachaise J, Graciaa A, Beattie JK, J. Phys. Chem., 111, 3753 (2007)
Kim K, Kim Y, Yang J, Ha KS, Usta H, Lee J, Kim C, J. Ind. Eng. Chem., 46, 350 (2017)

[Referenced By]

[1] Drogaris G, Weiland P, Chem. Eng. Sci., 38, 1501 (1983)

[2] Fei Q, Guarnieri MT, Tao L, Laurens LM, Dowe N, Pienkos PT, Biotechnol. Adv., 32, 596 (2014)

[3] Ahmed A, Lewis RS, Biotechnol. Bioeng., 97(5), 1080 (2007)

[4] Van Hamme JD, Singh A, Ward OP, Microbiol. Mol. Biol. Rev., 67, 503 (2003)

[5] Logan BE, Microbial Fuel Cells, John Wiley & Sons, 2008.

[6] Worden R, Bredwell M, Grethlein A, Engineering issues in synthesis-gas fermentations, in: ACS Symposium Series, 1997, ACS Publications.

[7] Bosma TN, Middeldorp PJ, Schraa G, Zehnder AJ, Environ. Sci. Technol., 31, 248 (1996)

[8] Bouaifi M, Hebrard G, Bastoul D, Roustan M, Chem. Eng. Process., 40(2), 97 (2001)

[9] Heerschap S, Marafino JN, McKenna K, Caran KL, Feitosa K, Colloids Surf. A: Physicochem. Eng. Asp., 487, 190 (2015)

[10] (a) Dehghani F, Foster NR, Curr. Opin. Solid. State Mater. Sci. 7 (2003) 363; (b) Ohgaki K, Takano K, Sangawa H, Matsubara T, Nakano S, J. Chem. Eng. Jpn. 29 (1996) 478; (c) Michaels AS, Vieth WR, Barrie JA, J. Appl. Phys. 34 (1963) 1.

[11] (a) Yakahashi M, J. Phys. Chem. B 109 (2005) 21858; (b) Chen X, Hussein M, Becker T, Eng. Life Sci. 00 (2017) 1.

[12] Graciaa A, Morel G, Saulner P, Lachaise J, Schechter RS, J. Colloid Interface Sci., 172(1), 131 (1995)

[13] Yang C, Dabros T, Li DQ, Czarnecki J, Masliyah JH, J. Colloid Interface Sci., 243(1), 128 (2001)

[14] Henderson RK, Parson SA, Refferson B, Environ. Sci. Technol., 42, 4883 (2008)

[15] (a) Kim K, Lee J, Seo K, Kim MG, Ha KS, Kim C, J. Ind. Eng. Chem. 33 (2016) 326; (b) Baz-Rodriguez SA, Botello-Alvarez JE, Estrada-Baltazar A, Vilchiz- Bravo LE, Padilla-Medina JA, Miranda-Lopez R, Chem. Eng. Res. Des. 11 (2014) 2352.

[16] (a) Zhu H, Shanks BH, Heindel TJ, Ind. Eng. Chem. Res. 48 (2009) 3206; (b) Craig V, Ninham B, Pashley R, Nature 364 (1993) 317.319.

[17] (a) Ducker WA, Xu Z, Israelachvili JN, Langmuir 10 (1994) 3279; (b) Du X, Zhao L, He X, Chen H, Fang W, Li X, Chem. Eng. J. 160 (2017) 72.

[18] (a) Vittal R, Gomathi H, Kim K, Adv. Colloid Interface Sci. 119 (2006) 55; (b) Ninham BW, Pashley RM, Nostro PL, Curr. Opin. Colloid & Interface Sci. 27 (2017) 25.

[19] Asgharpour M, Mehrnia MR, Mostoufi N, Biochem. Eng. J., 49, 351 (2010)

[20] (a) Jasna H, Ivankovic T, Open Life Sci. 2 (2007) 405; (b) Nye JV, Guerin WF, Boyd SA, Environ. Sci. Technol. 28 (1994) 944; (c) Tozum-Calgan SRD, Atay-Guneyman NZ, J. Environ. Sci. Health A 29 (1994) 355.

[21] Anastasiou AD, Kazakis NA, Mouza AA, Paras SV, Chem. Eng. Sci., 65(22), 5872 (2010)

[22] Cho S, Kim J, Chun J, Kim J, Colloids Surf. A: Physicochem. Eng. Asp., 269, 28 (2005)

[23] Lee J, Kim K, Chang IS, Kim MG, Ha KS, Lee EY, Lee JW, Kim C, J. Mol. Liq., 215, 154 (2016)

[24] (a) Riet KV, Ind. Eng. Chem. Process Des. Dev. 18 (1979) 357; (b) Kim K, Kwon T, Sung BJ, Kim C, J. Colloid Interface Sci. 15 (2017) 113.

[25] Hwang IY, Hur DH, Lee JH, Park CH, Chang IS, Lee JW, Lee EY, J. Microbiol. Biotechnol., 25, 375 (2015)

[26] Kadic E, Heindel TJ, An Introduction to Bioreactor Hydrodynamics and Gas. Liquid Mass Transfer, John Wiley & Sons, 2014.

[27] Yasin M, Park S, Jeong Y, Lee EY, Lee J, Chang IS, Bioresour. Technol., 169, 637 (2014)

[28] Creux P, Lachaise J, Graciaa A, Beattie JK, J. Phys. Chem., 111, 3753 (2007)

[29] Kim K, Kim Y, Yang J, Ha KS, Usta H, Lee J, Kim C, J. Ind. Eng. Chem., 46, 350 (2017)